Vermont Castings 2080 Specifications

Do Not Discard This Manual: Retain for Future Use2000888 5/06 Rev. 13Winter WarmSmall InsertFor Use in North America0888WinterWarmSmall Insertcov

10WinterWarm Small Insert2000888The FansTwo fans deliver a steady stream of warm air into the room. Use the fall-away handle, (used to operate the dam

11WinterWarm Small Insert2000888How To Build and Sustain a Wood Fire A WinterWarm Small Insert leaves the factory with the combustor installed.In the

12WinterWarm Small Insert2000888Follow these guidelines as you start and maintain the fire, and remove the ashes.1. Open the stove damper, and open th

13WinterWarm Small Insert2000888In Fireplace Insert installations, over-sized chimneys can produce less effective results than those that are properly

14WinterWarm Small Insert2000888MaintenanceKeep Your WinterWarm Small Insert Look-ing New and Working Its BestCare of the Cast Iron SurfaceAn occasion

15WinterWarm Small Insert2000888Adjust the Damper as NeededExamine your WinterWarm Small Insert’s damper after the first 50 hours of use and adjust it

16WinterWarm Small Insert2000888How to Replace Gaskets Your WinterWarm Small Insert uses rope-type fiber-glass gaskets to make a tight seal between som

17WinterWarm Small Insert2000888Care of the Catalytic Combustor Your wood heater contains a catalytic combustor which should be inspected regularly a

18WinterWarm Small Insert2000888If replacement of the refractory package is required, proceed to #10.10. Remove 1/4-20 x 1/2” hex head screw from the

19WinterWarm Small Insert2000888• Disconnect the flue liner or vent connector from the flue collar of the stove.• Slide the firechamber forward until y

2WinterWarm Small Insert2000888IntroductionSave These Instructions for Future ReferenceThe WinterWarm Small Insert is designed, tested and listed for

20WinterWarm Small Insert2000888Appendix: Catalytic CombustorIn any chemical reaction, including the combustion process, there are certain conditions

21WinterWarm Small Insert2000888CFM Corporation reserves the right to make changes in design, materials, specifications, prices and discontinue colors

22WinterWarm Small Insert2000888WinterWarm Small InsertModel 2080 (continued) Item Description Part Number 25. Coil & Shaft, Thermostat Assy

23WinterWarm Small Insert2000888Warranty Limited 3 Year WarrantyCFM Corporation warrants that this woodburning stove will be free of defects in materi

© CFM Corporation2695 Meadowvale Blvd. • Mississauga, Ontario, Canada L5N 8A3 800-668-5323 • www.cfmcorp.comCFM Corporation

3WinterWarm Small Insert2000888SpecificationsWinterWarm Small InsertEPA Emissions Rating ...gph, catalytic 2.1*Range of heat output

4WinterWarm Small Insert2000888Installing the WinterWarm Small Insert into an existing masonry or factory-built fireplace is an effective way to add an

5WinterWarm Small Insert2000888 When the insert is installed in a factory-built fire-place:• The factory-built chimney must meet type HT requirement

6WinterWarm Small Insert2000888A,IBCD,JED,JHCEFP1084winterwarmfireplace minimum dimensions3/01Fireplace MinimumsA. Width at Face 26¹⁄₂” (673mm)B.

7WinterWarm Small Insert2000888The approved construction of a floor protector calls for a minimum of 24 gauge galvanized sheet metal or equivalent such

8WinterWarm Small Insert20008883. Install the Chimney Connector Starter Pipe. (Not supplied)• Mark and drill two 5/16”, (8mm) holes 1⁵⁄₈” (41mm) fro

9WinterWarm Small Insert2000888OperationYour WinterWarm Insert’s Controls and What They DoAll WinterWarm Small Insert controls are conveniently locate