Vermont Castings Stardance SDV30 Operations Instructions

INSTALLER / CONSUMER SAFETY INFORMATIONPLEASE READ THIS MANUAL BEFORE INSTALLING AND USING APPLIANCE.WARNING!IF THE INFORMATION IN THIS MANUAL IS NOT

10Stardance Direct Vent/Natural Vent Gas Heater20007065General Venting Information - Termination LocationVVVVVVVXXXDEBBBCBMBAJKFLVENT TERMINATION AIR

11Stardance Direct Vent/Natural Vent Gas Heater20007065Fig. 10 Termination clearances.Venting Requirements - Natural Vent OnlyFP567NVBR/NVBC VENTING

12Stardance Direct Vent/Natural Vent Gas Heater20007065Venting Requirements and Options - Direct Vent ONLYApproved Vent System ComponentsThe Stardance

13Stardance Direct Vent/Natural Vent Gas Heater20007065Install the Optional FanIf you are installing the optional convection Fan Kit #2767 (FK26), co

14Stardance Direct Vent/Natural Vent Gas Heater20007065Venting System Assemlby - Direct VentGeneral InformationThe Stardance is approved for installat

15Stardance Direct Vent/Natural Vent Gas Heater20007065Install the Vent Adapter Pipe (Simpson Dura-Vent Components)1. Install the Restrictor Plate. C

16Stardance Direct Vent/Natural Vent Gas Heater20007065For DuraVent pipe only: Install vent pipe by aligning the locking system together, sliding the

17Stardance Direct Vent/Natural Vent Gas Heater20007065Vent Termination Below GradeInstall Snorkel Kit #7FSDVSKS when it is not possible to meet the r

18Stardance Direct Vent/Natural Vent Gas Heater200070659. Install the storm collar and seal around the joints. (Fig. 31)10. Add additional vent lengt

19Stardance Direct Vent/Natural Vent Gas Heater20007065Install the Vent PipeApply a bead of sealant around bottom end of inner starter pipe (found in

2Stardance Direct Vent/Natural Vent Gas Heater20007065PLEASE READ THE INSTALLATION & OPERATING INSTRUCTIONS BEFORE USING APPLIANCE.Thank you and c

20Stardance Direct Vent/Natural Vent Gas Heater20007065In the U.S.; Gas connection should be made in ac-cordance with current National Fuel Gas Code,

21Stardance Direct Vent/Natural Vent Gas Heater200070658. The air shutter is located on the bottom of the burner to the left. Unfasten the two nuts h

22Stardance Direct Vent/Natural Vent Gas Heater20007065Thermostat Connection (optional)Use only a thermostat rated for 500 millivolts.Check the table

23Stardance Direct Vent/Natural Vent Gas Heater20007065OperationThe Stardance is operated with the operable door front plate in place with the doors o

24Stardance Direct Vent/Natural Vent Gas Heater200070653. Open control access panel.4. Push in gas control knob slightly and turn clock-wise to “O

25Stardance Direct Vent/Natural Vent Gas Heater20007065Troubleshooting / Honeywell #8420 Gas Control SystemNOTE: Before troubleshooting the gas contro

26Stardance Direct Vent/Natural Vent Gas Heater20007065Instructions for RF Comfort Control ValveThe Comfort Control valve allows remote control of tem

27Stardance Direct Vent/Natural Vent Gas Heater20007065Auto ModeIn the AUTO mode, the room temperature, set tem-perature, flame and fan levels will be

28Stardance Direct Vent/Natural Vent Gas Heater20007065Comfort Valve System Control Sequence of Operation with TransmitterSet manual switch to local o

29Stardance Direct Vent/Natural Vent Gas Heater20007065If the manual switch is set to REMOTE, press the mode button to display AUTO on the transmitter

3Stardance Direct Vent/Natural Vent Gas Heater20007065General InformationThe Stardance Direct Vent/Natural Vent Room Heater, Model Nos. 3900-3916, 39

30Stardance Direct Vent/Natural Vent Gas Heater20007065Fuel Conversion InstructionsWARNING! This conversion kit shall be installed by a qualified servi

31Stardance Direct Vent/Natural Vent Gas Heater20007065FC107SIT820valve conversion10/03 ABCOFFPILOTOFig. 55 Remove mounting screws, pressure regula

32Stardance Direct Vent/Natural Vent Gas Heater20007065Models 3940, 3950 (RF Models) Only16. Follow procedure for pilot type 2 to replace pilot orifice

33Stardance Direct Vent/Natural Vent Gas Heater20007065MaintenanceYour Stardance Gas Heater will provide years of service with minimal upkeep. The fol

34Stardance Direct Vent/Natural Vent Gas Heater20007065ST208glass swivel latch12/99ST208Fig. 64 Release the latches to release the glass frame.Gask

35Stardance Direct Vent/Natural Vent Gas Heater20007065OFFONThermostat(Optional)ThermopileBlackBlackMillivoltGas ValveSt124bon/off/switchwiring1

36Stardance Direct Vent/Natural Vent Gas Heater200070651a1b1cPILOTONOFFPILOTADJLOHICEMENT2567198a,b20418217065Stardance fully assembledparts1/6/04 djt

37Stardance Direct Vent/Natural Vent Gas Heater20007065 2. Gasket Cement 1206122 3. Manifold Assembly 20003739 4. Lava Rocks Burner 57897 5.

38Stardance Direct Vent/Natural Vent Gas Heater20007065Stardance Direct Vent/Natural Vent Gas Heater (SDV30)Models 3900-3916, 3940-3956 (continued) R

39Stardance Direct Vent/Natural Vent Gas Heater20007065Optional AccessoriesFan KitsFK26 FanThe FK26 fan helps distribute heated air from within the fir

4Stardance Direct Vent/Natural Vent Gas Heater20007065Stardance Direct Vent / Natural Vent Dimensions9"(229 mm)CLValve Inlet26"(680 mm)25

40Stardance Direct Vent/Natural Vent Gas Heater20007065

41Stardance Direct Vent/Natural Vent Gas Heater20007065

42Stardance Direct Vent/Natural Vent Gas Heater20007065BASIC WARRANTY CFM Corporation (hereinafter referred to collectively as the Company) warrants

43Stardance Direct Vent/Natural Vent Gas Heater20007065GARANTIE DE BASE La société CFM Corporation (ci-après la « Société ») garantit votre nouveau p

Efficiency Ratings Model EnerGuide Ratings Fireplace Efficiency (%) SDV30RN 63.0 SDV30RP 63.0 SDV30RFN 63.0 SDV30RFP 63.0410 Admiral Blvd.

5Stardance Direct Vent/Natural Vent Gas Heater20007065Clearance RequirementsMinimum Clearances to Combustible MaterialsMeasure side clearances as show

6Stardance Direct Vent/Natural Vent Gas Heater20007065ST128bStardanceflue centerline9/28/00 djtCLCLBDCAParallel Installation: Minimum Clearance and

7Stardance Direct Vent/Natural Vent Gas Heater20007065Weight: Fully assembled; 202 lbs.Gas Specifications Max. Min. Input Input Model

8Stardance Direct Vent/Natural Vent Gas Heater20007065Vertical Termination - Direct Vent ONLYA vertical vent system must terminate no less than 8’ (2.

9Stardance Direct Vent/Natural Vent Gas Heater20007065Vent Termination ClearancesYour stove is approved to be vented either through the side wall, or